Description
Warranty & Shipping
How-To & Tools
Product Reviews
Q&A
Vehicle Fit

This air pump is one of the highest quality replacements on the market!

Specifications:

  • Secondary Air Pump
  • Has 2-Pin 45 Degree Angle Plug Connector
  • Replaces dealer part numbers: 06A959253B, 06A959253E
  • Direct replacement
  • Built to strict quality control standards

This air pump motor assembly is built to strict quality control standards, makes a great replacement, and has substantial cost savings over an AIR pump assembly from the dealer.

Item Condition: New

Attention California Customers:

WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov.

Lifetime Warranty

This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser.

  1. step : Checking the AIR Pump Fuse (1:07)
    • Remove the cover from the relay box
    • Remove the AIR pump fuse
    • Check the fuse
    • Replace the fuse if necessary
  2. step : Removing the Wheel (1:57)
    • Pry off the center cap with a flat blade screwdriver
    • Loosen the lug nuts with the vehicle on the ground
    • Raise the vehicle with a floor jack
    • Secure the vehicle on jack stands
    • Remove the lug nuts
    • Pull off the wheel
  3. step : Opening the Wheel Well (2:06)
    • Remove two 7mm bolts from the wheel well
    • Remove three 7mm bolts from below the bumper
    • Remove the two 7mm from the inner fender
    • Pull out on the bumper cover and pull the inner fender out of the way
    • Remove two 10mm bolts from the AIR pump
  4. step : Removing the Headlight (3:18)
    • Pry the clip out of the hood trim
    • Pull the plastic clips off of the headlight
    • Pull the headlight out
    • Disconnect the headlight wiring harness
  5. step : Removing the AIR Pump (4:03)
    • Remove the 10mm bolt from the headlight
    • Disconnect the AIR pimp wiring harness
    • Disconnect the intake hose from the pump
    • Disconnect the exhaust hose from the pump
  6. step : Preparing the New AIR Pump (5:30)
    • Pull the old pump out of its mounting bracket
    • Remove the rubber grommets from the old pump
    • Install the rubber grommets on to the new pump
    • Apply penetrating oil to the T25 Torx bolts on the old pump
    • Remove the four T25 Torx bolts from the old pump
    • If the screws strip, drill them out
    • Remove the housing from the old pump
    • Remove the gasket from the housing
    • Install the new gasket into the housing
    • Place the pump on the housing
    • Start the four T25 Torx bolts by hand
    • Tighten the four T25 Torx bolts
    • Connect the new pump to the mounting bracket
  7. step : Installing the New AIR Pump (9:15)
    • Check the hoses for any debris
    • Clear the hoses if necessary
    • Put the new pump into place
    • Start the 10mm bolt under the headlight area
    • Connect the hoses to the pump
    • Tighten the hose clamps
    • Tighten the 10mm bolt at the front of the pump
    • Connect the pump wiring harness
    • Clip the harness on to the mounting bracket
  8. step : Installing the Headlight (10:13)
    • Connect the headlight wiring harness
    • Insert the plastic headlight clips
    • Put the hood trim into place
    • Insert the hood trim clip
  9. step : Closing the Wheel Well (10:28)
    • Insert the two 10mm bolts into the side of the pump bracket
    • Push the inner fender into place
    • Insert the 7mm bolts into the inner fender
  10. step : Reattaching the Wheel (11:26)
    • Slide the wheel into place
    • Start the lug nuts by hand
    • Tighten the lug nuts preliminarily
    • Lower the vehicle to the ground
    • Tighten the lug nuts to between 100 foot-pounds in a crossing or star pattern
    • Reattach the center cap
  11. step : Checking the AIR Pump Fuse (11:53)
    • Remove the cover from the relay box
    • Remove the AIR pump fuse
    • Check the fuse
    • Replace the fuse if necessary

Tools needed for replacement:

    Drills, Drill Bits & Related

  • Drill

  • Materials, Fluids, and Supplies

  • Rust Penetrant

  • Pliers, Cutters & misc Wrenches

  • Slip-Joint Pliers

  • Ratchets & Related

  • Ratchet

  • Screwdrivers & Related

  • Flat Blade Screwdriver

  • Sockets - Metric

  • 7mm Socket
  • 10mm Socket

  • Torx Drivers & Sockets

  • T25 Torx Driver

  • Wrenches - Metric

  • 7mm Wrench
  • 10mm Wrench

4.67/ 5.0
6 reviews
5 Stars
4 Stars
3 Stars
2 Stars
1 Star
4
2
0
0
0
Air Pump
The pump went in my 2001 beetle perfect, only took 20 minutes to change. My local garage wanted $400.00 for this pump sorry. 1A Auto was great.
February 9, 2017
Good enough..
Installed on VW Passat. Everything connected fine except the output hose. Connector would not stay seated on the pump. I used electrical tape to secure it and it is working fine.
March 11, 2018
100% satified
Great timing on delivery, 1aauto has made buying parts very easy and affordable so that anyone can do it, the reps are great and I definitely would recommend and I have been ferering 1aauto to friends and even people looking for quality and very affordable parts.
March 26, 2018
Great product
Works great! Exactly what we ordered! Fast shipping
August 19, 2018
wheel bearings
every thing went well , be nice if bearing come with new hardware
September 7, 2018
Everything as Promised
Easy to find on the website, price was right and fit perfect. First purchase from 1A auto and was delivered fast. Installed it, cleared the codes and is working flawlessly. Will use 1A auto again!
September 15, 2018
Will this fit my car? Add a vehicle to make sure
Customer Q&A
Ask a question to 1A Auto customers who purchased the product
What if I order the wrong one?
Roberta S May 4, 2016
We supply an OEM factory part number for you to reference if you chose to call your local dealer parts department and verify however we do understand human error. If you get a part that will not work for your model application, and its still new, uninstalled and clean, we will be more than happy to take it back for a full part refund
Brian F May 5, 2016
Year Make Model Description
2000Audi A4 Audi A4 Secondary Pump Electric Air Pump (From VIN 100001)
2001-2005Audi A4 Audi A4 Secondary Pump Electric Air Pump
2006Audi A4 Audi A4 Secondary Pump Electric Air Pump L4 1.8L
2000Audi A4 Quattro Audi A4 Quattro Secondary Pump Electric Air Pump (From VIN 100001)
2001-2005Audi A4 Quattro Audi A4 Quattro Secondary Pump Electric Air Pump
2006Audi A4 Quattro Audi A4 Quattro Secondary Pump Electric Air Pump L4 1.8L
2006Audi A4 Quattro Audi A4 Quattro Quattro Secondary Pump Electric Air Pump V6 3.0L
2000Audi A6 Audi A6 Secondary Pump Electric Air Pump V6 2.8L (From VIN 120001)
2001Audi A6 Audi A6 Secondary Pump Electric Air Pump V6 2.8L
2002-2004Audi A6 Audi A6 Secondary Pump Electric Air Pump for Models with V6 3.0L & 5 Speed Automatic Transmission
2005-2012Audi A6 Audi A6 Secondary Pump Electric Air Pump V8 4.2L
2000Audi A6 Quattro Audi A6 Quattro Secondary Pump Electric Air Pump V6 2.8L (From VIN 120001)
2001Audi A6 Quattro Audi A6 Quattro Secondary Pump Electric Air Pump V6 2.8L
2002-2004Audi A6 Quattro Audi A6 Quattro Secondary Pump Electric Air Pump for Models with V6 3.0L & 5 Speed Automatic Transmission
2005-2012Audi A6 Quattro Audi A6 Quattro Secondary Pump Electric Air Pump V8 4.2L
2005-2009Audi A8 Quattro Audi A8 Quattro Secondary Pump Electric Air Pump W12 6.0L
2006-2010Audi A8 Quattro Audi A8 Quattro Secondary Pump Electric Air Pump V8 4.2L
2001-2002Audi Cabriolet Audi Cabriolet Secondary Pump Electric Air Pump
2007-2008Audi Q7 Audi Q7 Secondary Pump Electric Air Pump V8 4.2L
2004-2006Audi TT Quattro Audi TT Quattro Quattro Secondary Pump Electric Air Pump V6 3.2L (5th Vin Digit D)
2000-2005Volkswagen Beetle VW Beetle Secondary Pump Electric Air Pump L4 2.0L
2001Volkswagen Beetle VW Beetle Secondary Pump Electric Air Pump L4 1.8L (Engine ID AWV)
2002-2005Volkswagen Beetle VW Beetle Secondary Pump Electric Air Pump L4 1.8L
2001-2002Volkswagen Cabrio VW Cabrio Secondary Pump Electric Air Pump
2001Volkswagen Eurovan VW Eurovan Secondary Pump Electric Air Pump V6 2.8L (Engine ID AKX)
2002-2003Volkswagen Eurovan VW Eurovan Secondary Pump Electric Air Pump
2000-2001Volkswagen Golf VW Golf Hatchback Secondary Pump Electric Air Pump L4 2.0L
2002-2005Volkswagen Golf VW Golf Secondary Pump Electric Air Pump L4 2.0L
2003-2005Volkswagen Golf VW Golf Secondary Pump Electric Air Pump V6 2.8L
2004Volkswagen Golf VW Golf Secondary Pump Electric Air Pump V6 3.2L
2006Volkswagen Golf VW Golf Secondary Pump Electric Air Pump L4 2.0L (8th Vin Digit J)
2000-2005Volkswagen Jetta VW Jetta Secondary Pump Electric Air Pump L4 2.0L
2002-2005Volkswagen Jetta VW Jetta Secondary Pump Electric Air Pump V6 2.8L (Engine ID BDF)
2000Volkswagen Passat VW Passat Secondary Pump Electric Air Pump (From VIN 250001)
2001-2005Volkswagen Passat VW Passat Secondary Pump Electric Air Pump
2004-2009Volkswagen Touareg VW Touareg Secondary Pump Electric Air Pump V8 4.2L
2004-2006Volkswagen Touareg VW Touareg Secondary Pump Electric Air Pump V6 3.2L
Part #: 1AEAP00004


Order must be placed by 4pm ET

Get it in: 2 - 4 Business Days

Want it sooner? Choose Next Day Air at Checkout

How-to Video:

(12:20 min)