Specifications

  • RH (Passenger Side)
  • Includes lens, housing
  • Bulbs not included
  • For 2001 models, fits vehicles with VIN up to 049999

Fit guaranteed

  • This headlamp will install just as your original does. You can use your existing hardware and wiring harnesses.
  • Save time and money with a direct fit. No trips to the hardware store or extra time trying to get the wiring to hookup.

Quality

  • 1A Auto has the most comprehensive warranty.
  • If this headlight should fail to provide satisfactory performance you may exchange it.
  • 1A Auto Headlights are guaranteed to pass inspections in all 50 states. DOT (U.S. Dept. of Transportation) and SAE (Society of Automotive Engineers) approved.

Value

  • Replacing a discolored, scratched, dull or damaged headlight with a headlight from 1A Auto can increase your resale value by up to 10%.

Safety

  • A new headlight can provide you with up to 50% more illumination than a dull, yellowed, sandblasted, broken or scratched headlight.
    • 1A Auto headlights can help you see farther at night and in poor driving conditions.
    • A new headlight from 1A Auto can make you more visible to other traffic during heavy rain or wintry weather..
Direct Fit Replacement

Direct fit replacement for OEM assembly

Trouble-free Installation

Uses same wiring as original assembly.  No cutting or splicing required.

DOT and SAE Compliant

Meets federal regulations for on-road use

Part Details

Lifetime Warranty

This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser.

Bulb Note:

Unless otherwise noted, our lights do not include bulbs, though occasionally lighting manufacturers do include bulbs in the lights. If you happen to receive a lighting product (Headlight, Tail light, parking light, fog light etc.) that comes with the bulbs, the bulbs are not covered under our warranty. Our warranty applies only to the light assembly..

  1. step : Replacing Drivers Side Headlight Bulbs (1:07)
    • Remove the dust cover
    • Squeeze retainer clip
    • Pull the light out carefully.
    • Bulb pulls free from socket
    • Replace bulb
    • Put the light back into place by squeezing the retainer clip
    • But the dust cover back on
  2. step : Replacing Passenger Side Headlight Bulbs (2:56)
    • Remove the air intake panel
    • Using a Phillips screwdriver remove the screws on the air intake duct behind light
    • Remove the dust cover
    • Squeeze retainer clip
    • Pull the light out carefully.
    • Bulb pulls free from socket
    • Replace bulb
    • Put the light back into place by squeezing the retainer clip
    • But the dust cover back on
    • Line up and replace the air intake duct and screws
  3. step : Removing a Headlight Assembly (4:15)
    • Pull the white ring behind the headlight
    • Reach in behind the light and pull the side light free
    • Remove the two caps above the light to access the screws
    • Remove the two T20 screws on the top and the one on the side of the headlight
    • Pull the light free. First away from the grill and then out
    • Disconnect the wires
  4. step : Reinstalling a Headlight Assembly (5:52)
    • Plug the wiring harness in to the light
    • Line up the tabs on the light and push it into place. Sliding the light to the side to secure it
    • Replace the T20 screws by hand, and tighten firmly
    • Twist the bulb for the side light back into the assembly
    • Line up the tabs and push the light in to place
    • Pull back the white ring and latch it to secure the light
    • Replace the screw caps
  5. step : Aiming Your Headlights (7:30)
    • Park 20' from a wall
    • Using a Phillips screw driver in the holes above the light, adjust the angle
    • One adjusts the light vertically
    • The other adjusts the light horizontally
    • Low beam should be pointing straight ahead. The concentration of light should be one inch below the bulb
    • High beam should be pointing straight ahead. The concentration of light should be lined up with the bulb

Tools needed for replacement:

    Screwdrivers & Related

  • Phillips Head Screwdriver

  • Torx Drivers & Sockets

  • T20 Torx Driver

There are no reviews for this item. Write Review
Start typing your question and we'll check if it was already asked and answered. Learn More
No questions have been asked about this item. Be the first!

Vehicle Fit

  • 1998-2000 VW Passat Headlight Passenger Side
  • 2001 VW Passat (Built Before VIN 049999) Headlight Passenger Side

This part replaces:

  • Partslink VW2503112
  • Hollander 114-58535R
  • OE # 3B0 941 018 Q
  • TYC 20-5763-01
  • DEPO 341-1105R-AS
Part #: 1ALHL00730

How-to Video:

(08:26 min)