Replaces

Volkswagen Beetle Golf Jetta Engine Oil Pan - 1AEOP00134

Description
Warranty & Shipping
How-To & Tools
Product Reviews
Q&A
Vehicle Fit

This replacement oil pan is among the highest quality replacements on the market. It's just what you need to get your engine in good working order again!

Specifications:

  • Brand New Oil Pan
  • Gasket not included
  • Replaces dealer part number: 06A103601T
  • Direct replacement
  • Built to strict quality control standards
  • Fits models with L4 2.0L Engine only

Replace your leaking or damaged oil pan now with this great fitting alternative. It makes a great replacement and has good cost savings over a dealer unit.

Item Condition: New

WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov.

Lifetime Warranty

This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser.

  1. step : Draining the Oil (0:43)
    • Raise and secure the vehicle
    • Have a drain pan ready
    • Remove the drain plug with a 8mm Allen bit
    • Allow the oil to drain
    • Insert the drain plug
  2. step : Removing the Splash Shield (1:14)
    • Remove the T25 bolts from the splash shield
    • Pull out the splash shield
  3. step : Removing the Oil Pan (1:36)
    • Remove the three 16mm bolts on the side of the oil pan
    • Remove the two 5mm Allen bolts that hold the pipe to the oil pan
    • Remove the 10mm bolts from the oil pan, using a socket extension and swivel where necessary
    • Insert two bolts a couple turns into the oil pan in opposite corners
    • Separate the oil pan from the block with a pry bar
    • Remove the two place holder bolts
    • Separate the oil pan completely with the pry bar
    • Scrape off the gasket and seals with a razor blade
  4. step : Preparing the New Oil Pan (4:17)
    • Apply RTV to the top of the oil pan
    • Circle each bolt hole
    • Check that there are no gaps
  5. step : Installing the New Oil Pan (4:57)
    • Clean the oil pan mounting area
    • Push the oil pan into place
    • Start threading all the bolts in an opposing or crossing pattern
    • Insert the three 16mm bolts into the side of the oil pan
    • Tighten the 16mm bolts to 50 foot-pounds of torque
    • Tighten the 10mm bolts to 20 foot-pounds
    • Apply RTV to the pipe mounting area
    • Push the pipe into place
    • Insert the two bolts into the pipe and tighten them with the 5mm Allen bit
  6. step : Reinstalling the Splash Shield (7:13)
    • Clip the splash shield into place
    • Insert the T25 bolts into the splash shield
  7. step : Refilling the Oil (7:31)
    • Lower the vehicle to the ground
    • Remove the oil cap
    • Refill the oil using a funnel
    • Replace the oil cap
    • Run the engine briefly
    • Remove the oil dipstick
    • Check the oil level
    • Add oil as necessary

Tools needed for replacement:

    Allen Wrenches

  • 5mm Allen Wrench
  • 8mm Allen Wrench

  • General Tools

  • Jack Stands
  • Funnel
  • Floor Jack
  • Drain Pan
  • Razor Blade / Gasket Scraper

  • Materials, Fluids, and Supplies

  • Cloth Rags
  • RTV

  • Ratchets & Related

  • Ratchet
  • Torque Wrench
  • Socket Extensions
  • Swivel

  • Screwdrivers & Related

  • Pry Bar

  • Sockets - Metric

  • 16mm Socket
  • 10mm Socket

  • Torx Drivers & Sockets

  • T25 Torx Driver

There are no reviews for this item.
Will this fit my car? Add a vehicle to make sure
Customer Q&A
Ask a question to 1A Auto customers who purchased the product
No questions have been asked about this item.
Year Make Model Description
2004Volkswagen Beetle VW Beetle Hatchback Engine Oil Pan L4 2.0L
2005Volkswagen Beetle VW Beetle (Engine ID BEV) Engine Oil Pan L4 2.0L
2005Volkswagen Golf VW Golf (Engine ID BEV) Engine Oil Pan L4 2.0L
2006-2009Volkswagen Golf VW Golf Engine Oil Pan L4 2.0L (5th Vin Digit L)
2008-2011Volkswagen Golf VW Golf Engine Oil Pan L4 2.0L (Engine ID BEV) (5th Vin Digit K)
2004Volkswagen Jetta VW Jetta (Engine ID BEV) Engine Oil Pan L4 2.0L
2005Volkswagen Jetta VW Jetta (Engine ID BEV) Engine Oil Pan L4 2.0L (excluding Turbo Models)
2007-2011Volkswagen Jetta VW Jetta Engine Oil Pan L4 2.0L (Engine ID BEV) (5th Vin Digit K)
Part #: 1AEOP00134


Order must be placed by 4pm ET

Get it in: 2 - 4 Business Days

Want it sooner? Choose Next Day Air at Checkout

How-to Video:

(08:23 min)