MOPAR EGR VALVE: 4593892AA

Specifications:

  • Brand New EGR Valve
  • Replaces dealer part numbers: 4593563AA, 4593574AA, 4593574AC, 4593820AA, 4593820AB, 4593834AA, 4593834AC, 4593892AA, 4627320AA
  • Direct Fit
  • Built to strict quality control standards

If your vehicle is running rough or has failed emissions due to a bad EGR valve then this is the part for you.

The EGR valve in your vehicle is a critical part of the emission reduction system on your vehicle. At certain throttle levels the valve allows exhaust gasses to recirculate through the engine combustion process. This process is key in reducing Nitrogen Oxide emissions.

NOTE: If you need to match the 8th digit of your VIN (Vehicle Identification Number) to the 8th digit we may have listed in our short description, you can either find your VIN number in the lower driver side corner of the windshield or on your vehicle registration.

Our electrical and electronic parts are subject to strict quality control testing.  Once the item has been installed or plugged in, it is no longer eligible for a refund.  The item may be eligible for replacement, only if it is found to have a manufacturing defect. Before purchasing, please ensure proper diagnosis of the failed original part is performed

Lifetime Warranty

This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser. Please keep your invoice for proof of this warranty.

  1. step : Removing the Wiper Arm (0:49)
    • Mark the placement of the wiper arm with painter's tape
    • Remove the cap on the wiper arm
    • Remove the 15mm nut on the wiper arm
    • Push down on the joint of the arm to loosen it
    • Remove the arm
  2. step : Removing the Wiper Transmission (1:39)
    • Remove the nine pushpins from the cowl
    • Remove the Phillips screws from each corner of the cowl
    • Lift and remove the cowl from its metal clips
    • Disconnect the wiper transmission wiring harness
    • Remove the 10mm bolts from the wiper transmission
    • Lift the wiper transmission up and out
  3. step : Removing the EGR Tube (3:05)
    • Remove the 8mm bolts from the EGR Tube flange
    • Pull the top of the EGR tube out and remove the tube
  4. step : Removing the EGR Valve (4:45)
    • Remove the two 10mm bolts from the EGR valve
    • Press the red safety tab off the side and release the connector
    • Remove the EGR valve
  5. step : Installing the EGR Valve (7:31)
    • Insert the EGR valve and gasket into the engine head
    • Tighten the 10mm bolts to the EGR Valve
    • Connect the wiring harness and engage the red safety tab
  6. step : Installing the EGR Tube (8:34)
    • Reinstall the EGR Tube
    • Tighten the 8mm bolts to the EGR tube and gasket
  7. step : Installing the Wiper Transmission (9:22)
    • Insert the wiper transmission into place
    • Tighten the 10mm bolts to the transmission
    • Connect the wiring harness
    • Press the cowl panel into place
    • Tighten the Phillips screws to the cowl panel
    • Press on the pushpins
  8. step : Installing the Wiper Arm (11:12)
    • Insert the wiper arm to the studs
    • Tighten the 15mm bolt
    • Press on the wiper arm cover

Tools needed for replacement:

    Ratchets & Related

  • Swivel
  • Ratchet
  • Socket Extensions

  • Screwdrivers & Related

  • Flat Blade Screwdriver

  • Sockets - Metric

  • 8mm Socket
  • 15mm Socket

  • Specialty Tools

  • Trim Tool Set

There are no reviews for this item. Write Review
Start typing your question and we'll check if it was already asked and answered. Learn More
No questions have been asked about this item. Be the first!

Vehicle Fit

  • 2005-2010 Chrysler 300 EGR Valve V6 3.5L Mopar 4593892AA
  • 2005 Chrysler Sebring EGR Valve V6 2.7L Mopar 4593892AA
  • 2009-2010 Dodge Challenger EGR Valve V6 3.5L Mopar 4593892AA
  • 2006-2010 Dodge Charger EGR Valve V6 3.5L Mopar 4593892AA
  • 2005-2008 Dodge Magnum EGR Valve V6 3.5L Mopar 4593892AA
  • 2005 Dodge Stratus EGR Valve V6 2.7L Mopar 4593892AA

This part replaces:

  • Mopar 4593892AA
  • OE # 4593892AA
  • OE # 4593574AC
Only 1 left in stock
Part #: MPEGR00001

Ships Same Day for orders placed by 4 P.M. ET

Brand #: 4593892AA

How-to Video:

(12:16 min)