Replaces

1999-2005 Pontiac Grand Am Temperature Blend Door Actuator

This part replaces:

  • DORMAN 604-107
  • OE # 16177412
  • OE # 89018395
  • OE # 89018681

  • New

Specifications:

  • Brand New Temperature Blend Door Actuator
  • Controls the blend of hot & cold air into the vehicle
  • Direct fit replacement
  • Correct for models with manual A/C

Fit and Installation

  • This part is designed to replace the factory vent door actuator with no modification. Removing and replacing a vent door actuator is generally a repair that can be done by the customer. We have the same part but at a fraction of the cost from a mechanic or the dealer.


 

 

 

Left Hand Drive Note:

“All of our auto parts are intended for Left Hand Drive USDM vehicles and might not have been tested on Right Hand Drive platforms. If your vehicle is Right Hand Drive, please do your research prior to making a purchase to ensure the part is correct for your specific vehicle.”

Lifetime Warranty

This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser. Please keep your invoice for proof of this warranty.

  1. Removing the Wheel (0:43)
    • Pry off the hub cap with a flat blade screwdriver
    • Loosen the 35mm hub nut with the vehicle on the ground
    • Loosen the lug nuts
    • Raise the vehicle with a floor jack
    • Secure the vehicle on jack stands
    • Remove the lug nuts
    • Pull off the wheel
  2. Removing the Outer Tie Rod (1:08)
    • Spray both ends of the outer tie rod with penetrating oil
    • Measure from the either end of the outer tie rod
    • Place a 26mm wrench on the larger nut
    • Place a 22mm wrench on the smaller nut
    • Break the 22mm nut free
    • Straighten the cotter pin with pliers and pull it through
    • Remove the nut with a 21mm socket from the wheel knuckle
    • Hit the wheel knuckle with a hammer
    • Twist off the outer tie rod
    • Remove the 22mm nut off the outer tie rod
  3. Installing the New Outer Tie Rod (3:08)
    • Mark where the 22mm nut was located on the old tie rod to the new tie rod
    • Screw on the nut
    • Twist the outer tie rod into place
    • Push the outer tie rod into the wheel knuckle
    • Measure and check the outer tie rod distance
    • Tighten the 21mm nut on the wheel knuckle
    • Insert and twist the cotter pin with a pair of pliers
    • Tighten the two nuts on the outer tie rod
  4. Reattaching the Wheel (4:33)
    • Slide the wheel into place
    • Start the lug nuts by hand
    • Tighten the lug nuts preliminarily
    • Lower the vehicle to the ground
    • Tighten the hub nut
    • Torque the lug nuts to 100 ft/lbs in a crossing or star pattern
    • Torque the hub nut to 103 ft/lbs
    • Reattach the center cap

Tools needed for replacement:

    General Tools

  • Floor Jack
  • Hammer
  • Jack Stands
  • Measuring Tape

  • Materials, Fluids, and Supplies

  • Rust Penetrant

  • Pliers, Cutters & misc Wrenches

  • Needle nose pliers

  • Ratchets & Related

  • Ratchet
  • Torque Wrench

  • Screwdrivers & Related

  • Flat Blade Screwdriver

  • Sockets - Metric

  • 19mm Socket
  • 21mm Socket

  • Wrenches - Metric

  • 10mm Wrench
  • 22mm Wrench
  • 26mm Wrench

How-to Video:

(05:20 min)

Tools List:

    General Tools

  • Floor Jack
  • Hammer
  • Jack Stands
  • Measuring Tape

  • Materials, Fluids, and Supplies

  • Rust Penetrant

  • Pliers, Cutters & misc Wrenches

  • Needle nose pliers

  • Ratchets & Related

  • Ratchet
  • Torque Wrench

  • Screwdrivers & Related

  • Flat Blade Screwdriver

  • Sockets - Metric

  • 19mm Socket
  • 21mm Socket

  • Wrenches - Metric

  • 10mm Wrench
  • 22mm Wrench
  • 26mm Wrench



This part replaces:

  • DORMAN 604-107
  • OE # 16177412
  • OE # 89018395
  • OE # 89018681

Vehicle Fit

  • 1997-2005 Buick Century Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1997-2004 Buick Regal Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1999 Cadillac Escalade Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-1999 Chevy C1500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-2000 Chevy C2500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-2002 Chevy C3500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1997-2002 Chevy Corvette Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 2000-2003 Chevy Impala Temperature Blend Door Actuator
  • 1995-1999 Chevy K1500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-1999 Chevy K2500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-2000 Chevy K3500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1997-2003 Chevy Malibu Temperature Blend Door Actuator
  • 2000-2003 Chevy Monte Carlo Temperature Blend Door Actuator
  • 1995-1999 Chevy Suburban C1500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 Chevy Suburban C2500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 Chevy Suburban K1500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 Chevy Suburban K2500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 Chevy Tahoe Temperature Blend Door Actuator for Main Unit
  • 2000 Chevy Tahoe Temperature Blend Door Actuator for Main Unit V8 5.7L
  • 1997-2000 Chevy Venture Temperature Blend Door Actuator
  • 1995-1999 GMC C1500 Truck Temperature Blend Door Actuator
  • 1995-2000 GMC C2500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-2002 GMC C3500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-1999 GMC K1500 Truck Temperature Blend Door Actuator
  • 1995-2000 GMC K2500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-2000 GMC K3500 Truck Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1995-1999 GMC Suburban C1500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 GMC Suburban C2500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 GMC Suburban K1500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 GMC Suburban K2500 Temperature Blend Door Actuator for Main Unit
  • 1995-1999 GMC Yukon Temperature Blend Door Actuator
  • 2000 GMC Yukon Temperature Blend Door Actuator for Main Unit V8 5.7L
  • 1999-2004 Olds Alero Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1997-1999 Olds Cutlass Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1998-2002 Olds Intrigue Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1997-2000 Olds Silhouette Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1999-2005 Pontiac Grand Am Temperature Blend Door Actuator
  • 1997-2003 Pontiac Grand Prix Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1999-2000 Pontiac Montana Temperature Blend Door Actuator (without Automatic Temperature Control)
  • 1997-1998 Pontiac Trans Sport Temperature Blend Door Actuator (without Automatic Temperature Control)
$40.45
Save 48%
List: $77.26 Save: $36.81
Part #: 1AHCX00293

Ships Same Day for orders placed by 5 P.M. ET

Free GROUND SHIPPING

Check Shipping Rates

We're here to help

1A Auto Parts

Customer Feedback

Customer Feedback
"Thanks for the fast reliable service. Great price, and the headlights were as good as oem or better!!! Keep up the good work..."
- Dwuan M.
Read More
Free Shipping!
OR
CALL
TOLL
FREE

888-844-3393

hablamos Español:866-401-3393
SHIPS SAME DAY
For Orders Placed By 5pm Est