Replaces

2004-2005 Chevy Malibu New Body Style Radiator Dual Cooling Fan Assembly (4th Vin Digit Z)

This part replaces:

  • PARTSLINK GM3115178
  • DORMAN 620-610
  • OE # 15788745
  • HOLLANDER 674-00849

  • New

Our aftermarket radiator fan assemblies are some of the highest quality replacements on the market! This radiator cooling fan assembly is a complete, ready to bolt on, direct replacement part.

Specifications:

  • New, not rebuilt, electric motors
  • DUAL FAN
  • Replaces dealer part number: 15788745
  • Geometrically designed plastic blade for optimal circulation and uniform balance
  • Shroud designed to ensure structural integrity and endurance for maximum performance
  • 100% Performance factory tested
  • Replaces original assemblies that are melted or worn out
  • Comes with proper plug(s) for trouble free installation

Now you can buy a high quality radiator cooling fan motor assembly that is built to strict quality control standards. This cooling motor assembly makes a great replacement and has substantial cost savings over a dealer fan assembly.

Lifetime Warranty

This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser. Please keep your invoice for proof of this warranty.

  1. Disconnecting the Battery (0:57 in the video)
    • Remove the battery cover
    • Disconnect the negative battery cable
  2. Removing the Engine Cover (1:07 in the video)
    • Twist off the oil fill cap
    • Pull off the engine cover
    • Twist on the oil fill cap
  3. Removing the Headlight (1:15 in the video)
    • Remove the plastic clips from the bumper cover
    • Remove the two 7mm bolts from the passenger side headlight
    • Pull the headlight up and out
    • Disconnect the headlight wiring harness
  4. Removing the Radiator Closeout Panel (2:10 in the video)
    • Remove the four 10mm bolts from the radiator closeout panel
    • Pull the panel forward
    • Remove the three 10mm bolts from the hood latch assembly
    • Pull the clips out of the radiator panel with needle nose pliers
    • Pull the hood latch forward
    • Pull off the radiator panel
    • Pull the hood latch aside
  5. Removing the Air Duct (3:10 in the video)
    • Pull the pin out of the air duct with needle nose pliers
    • Pull the air duct forward and out
  6. Pulling the Radiator Aside (3:25 in the video)
    • Remove the two 10mm bolts from the radiator mounts
    • Pull off the radiator mounts
  7. Removing the Air Intake Hose (3:42 in the video)
    • Loosen the two hose clamps on the air intake hose with a flat blade screwdriver
    • Loosen the top air intake hose clamp with pliers
    • Pull off the air intake hose
  8. Disconnecting the Radiator Hose (4:11 in the video)
    • Have a drain pan ready
    • Loosen the upper radiator hose clamp with pliers
    • Pull the radiator hose off the radiator inlet
    • Allow some of the fluid to drain
    • Put the hose aside such that it stops draining
  9. Removing the Radiator Fan (4:50 in the video)
    • Disconnect the air bag sensor wiring harness safety clip
    • Disconnect the alternator wiring harness
    • Disconnect the airbag sensor wiring harnesses
    • Remove the 10mm nuts from the ground straps
    • Pull the ground straps off of the radiator support
    • Unclip the transmission line from the radiator fan
    • Disconnect the radiator fan wiring harnesses
    • Pull the radiator off of its bushings
    • Pull the radiator away from the radiator fan
    • Unclip the radiator fan from the radiator
    • Slide the fan to the passenger side
    • Tilt the fan forward
    • Pull the fan up and out
  10. Installing the New Radiator Fan (7:25 in the video)
    • Make sure the radiator fan has a clear path
    • Angle the fan into place
    • Slide the fan into place
    • Clip the radiator fan to the radiator
    • Clip the transmission line to the radiator fan
    • Connect the radiator fan wiring harnesses
    • Connect the alternator wiring harness
    • Put the ground straps onto the radiator support
    • Fasten the 10mm nuts onto the ground straps
    • Connect the air bag sensor wiring harnesses
    • Clip the air bag sensor wiring harnesses into place
    • Connect the air bag sensor wiring harness safety clip
  11. Positioning the Radiator (8:57 in the video)
    • Push the radiator onto its bushings
    • Put the passenger side radiator mount into place
    • Start the 10mm bolt into the radiator mount
    • Push the radiator hose onto the radiator inlet
    • Push the radiator hose clamp on with pliers
  12. Reinstalling the Radiator Mount (10:08 in the video)
    • Put the hood latch into place
    • Put the driver side radiator mount into place
    • Insert the 10mm bolt into the radiator mount
    • Tighten both radiator mount bolts
  13. Reinstalling the Air Duct (10:28 in the video)
    • Make sure the hood release cable stays routed underneath the air duct
    • Push the air duct into place
    • Push the pin into the air duct
  14. Reinstalling the Hood Latch (10:49 in the video)
    • Put the radiator panel into place
    • Start the three 10mm bolts into the hood latch
    • Position the hood latch
    • Tighten the three 10mm bolts
  15. Reinstalling the Headlight (11:35 in the video)
    • Connect the headlight wiring harness
    • Push the headlight into place starting on the inside
    • Insert the two 10mm bolts into the headlight
  16. Reinstalling the Radiator Panel (12:00 in the video)
    • Push the two pins into the radiator panel
    • Insert the four 10mm bolts into the radiator panel
    • Push the plastic clips into the radiator panel
  17. Reinstalling the Air Intake Hose (12:38 in the video)
    • Push the air intake hose into place
    • Push on the air intake hose clamps
  18. Reinstalling the Engine Cover (13:00 in the video)
    • Twist off the oil fill cap
    • Push on the engine cover
    • Twist on the oil fill cap
  19. Reconnecting the Battery (13:09 in the video)
    • Reconnect the negative battery cable
    • Push on the battery cover
  20. Refilling the Coolant (13:18 in the video)
    • Add coolant to the reservoir using a funnel
    • Run the car briefly
    • Fill the coolant as necessary

Tools needed for replacement:

    Pliers, Cutters & misc Wrenches

  • Needle nose pliers
  • Slip-Joint Pliers

  • Ratchets & Related

  • Ratchet

  • Screwdrivers & Related

  • Flat Blade Screwdriver
  • Phillips Head Screwdriver

  • Sockets - Metric

  • 10mm Socket
  • 7mm Socket
  • 8mm Socket
  • 9mm Socket

  • Specialty Tools

  • Flashlight

How-to Video:

(13:54 min)

Tools List:

    Pliers, Cutters & misc Wrenches

  • Needle nose pliers
  • Slip-Joint Pliers

  • Ratchets & Related

  • Ratchet

  • Screwdrivers & Related

  • Flat Blade Screwdriver
  • Phillips Head Screwdriver

  • Sockets - Metric

  • 10mm Socket
  • 7mm Socket
  • 8mm Socket
  • 9mm Socket

  • Specialty Tools

  • Flashlight



This part replaces:

  • PARTSLINK GM3115178
  • DORMAN 620-610
  • OE # 15788745
  • HOLLANDER 674-00849

Vehicle Fit

  • 2004-2005 Chevy Malibu New Body Style Radiator Dual Cooling Fan Assembly (4th Vin Digit Z)
  • 2006 Chevy Malibu Radiator Dual Cooling Fan Assembly for V6 3.5L
  • 2006-2008 Chevy Malibu Radiator Dual Cooling Fan Assembly for L4 2.2L
  • 2008-2012 Chevy Malibu Radiator Dual Cooling Fan Assembly for L4 2.4L
  • 2005 Pontiac G6 Sedan Radiator Dual Cooling Fan Assembly
  • 2006 Pontiac G6 Radiator Dual Cooling Fan Assembly for V6 3.5L
  • 2006-2010 Pontiac G6 Radiator Dual Cooling Fan Assembly for L4 2.4L
  • 2008-2009 Saturn Aura Radiator Dual Cooling Fan Assembly for L4 2.4L
$90.45
Save 73%
List: $330.22 Save: $239.77
Part #: 1ARFA00245

- Ships Same Day for orders placed by 5 P.M. ET

Free GROUND SHIPPING

Check Shipping Rates

We're here to help

Customer Feedback

Customer Feedback
"Thanks for the fast reliable service. Great price, and the headlights were as good as oem or better!!! Keep up the good work..."
- Dwuan M.
Read More
Free Shipping!
OR
CALL
TOLL
FREE

888-844-3393

hablamos Español:866-401-3393
SHIPS SAME DAY
For Orders Placed By 5pm Est