Replaces

2002-2005 VW Golf Secondary Electric Air Pump for L4 2.0L

This part replaces:

  • OE # 06A959253B
  • HOLLANDER 341-58088

  • New

This air pump is one of the highest quality replacements on the market!

Specifications:

  • Secondary Air Pump
  • Has 2-Pin 45 Degree Angle Plug Connector
  • Direct replacement
  • Built to strict quality control standards

This air pump motor assembly is built to strict quality control standards, makes a great replacement, and has substantial cost savings over an AIR pump assembly from the dealer.

Lifetime Warranty

Effective June 23, 2014: This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser. Please keep your invoice for proof of this warranty.

  1. Checking the AIR Pump Fuse
    • Remove the cover from the relay box
    • Remove the AIR pump fuse
    • Check the fuse
    • Replace the fuse if necessary
  2. Removing the Wheel
    • Pry off the center cap with a flat blade screwdriver
    • Loosen the lug nuts with the vehicle on the ground
    • Raise the vehicle with a floor jack
    • Secure the vehicle on jack stands
    • Remove the lug nuts
    • Pull off the wheel
  3. Opening the Wheel Well
    • Remove two 7mm bolts from the wheel well
    • Remove three 7mm bolts from below the bumper
    • Remove the two 7mm from the inner fender
    • Pull out on the bumper cover and pull the inner fender out of the way
    • Remove two 10mm bolts from the AIR pump
  4. Removing the Headlight
    • Pry the clip out of the hood trim
    • Pull the plastic clips off of the headlight
    • Pull the headlight out
    • Disconnect the headlight wiring harness
  5. Removing the AIR Pump
    • Remove the 10mm bolt from the headlight
    • Disconnect the AIR pimp wiring harness
    • Disconnect the intake hose from the pump
    • Disconnect the exhaust hose from the pump
  6. Preparing the New AIR Pump
    • Pull the old pump out of its mounting bracket
    • Remove the rubber grommets from the old pump
    • Install the rubber grommets on to the new pump
    • Apply penetrating oil to the T25 Torx bolts on the old pump
    • Remove the four T25 Torx bolts from the old pump
    • If the screws strip, drill them out
    • Remove the housing from the old pump
    • Remove the gasket from the housing
    • Install the new gasket into the housing
    • Place the pump on the housing
    • Start the four T25 Torx bolts by hand
    • Tighten the four T25 Torx bolts
    • Connect the new pump to the mounting bracket
  7. Installing the New AIR Pump
    • Check the hoses for any debris
    • Clear the hoses if necessary
    • Put the new pump into place
    • Start the 10mm bolt under the headlight area
    • Connect the hoses to the pump
    • Tighten the hose clamps
    • Tighten the 10mm bolt at the front of the pump
    • Connect the pump wiring harness
    • Clip the harness on to the mounting bracket
  8. Installing the Headlight
    • Connect the headlight wiring harness
    • Insert the plastic headlight clips
    • Put the hood trim into place
    • Insert the hood trim clip
  9. Closing the Wheel Well
    • Insert the two 10mm bolts into the side of the pump bracket
    • Push the inner fender into place
    • Insert the 7mm bolts into the inner fender
  10. Reattaching the Wheel
    • Slide the wheel into place
    • Start the lug nuts by hand
    • Tighten the lug nuts preliminarily
    • Lower the vehicle to the ground
    • Tighten the lug nuts to between 100 foot-pounds in a crossing or star pattern
    • Reattach the center cap
  11. Checking the AIR Pump Fuse
    • Remove the cover from the relay box
    • Remove the AIR pump fuse
    • Check the fuse
    • Replace the fuse if necessary

How-to Video:

(12:20 min)

Tools List:

    Drills, Drill Bits & Related

  • Drill

  • Materials, Fluids, and Supplies

  • Penetrating Oil

  • Pliers, Cutters & misc Wrenches

  • Slip-Joint Pliers

  • Ratchets & Related

  • Ratchet

  • Screwdrivers & Related

  • Flat Blade Screwdriver

  • Sockets - Metric

  • 10mm Socket
  • 7mm Socket

  • Torx Drivers & Sockets

  • T25 Torx Driver

  • Wrenches - Metric

  • 10mm Wrench
  • 7mm Wrench



This part replaces:

  • OE # 06A959253B
  • HOLLANDER 341-58088

Vehicle Fit

  • 2000 Audi A4 Secondary Electric Air Pump (From VIN 100001)
  • 2001-2005 Audi A4 Secondary Electric Air Pump
  • 2006 Audi A4 Secondary Electric Air Pump for L4 1.8L
  • 2006 Audi A4 Quattro Secondary Electric Air Pump for V6 3.0L
  • 2000 Audi A6 Secondary Electric Air Pump for V6 2.8L (From VIN 120001)
  • 2001 Audi A6 Secondary Electric Air Pump for V6 2.8L
  • 2002-2004 Audi A6 Secondary Electric Air Pump for Models with for V6 3.0L & Automatic 5 Speed Transmission
  • 2005-2012 Audi A6 Secondary Electric Air Pump for V8 4.2L
  • 2005-2009 Audi A8 Secondary Electric Air Pump for W12 6.0L
  • 2006-2010 Audi A8 Secondary Electric Air Pump for V8 4.2L
  • 2001-2002 Audi Cabriolet Secondary Electric Air Pump
  • 2007-2008 Audi Q7 Secondary Electric Air Pump for V8 4.2L
  • 2004-2006 Audi TT Quattro Secondary Electric Air Pump for V6 3.2L (5th Vin Digit D)
  • 2000-2005 VW Beetle Secondary Electric Air Pump for L4 2.0L
  • 2001 VW Beetle Secondary Electric Air Pump for L4 1.8L (Engine ID AWV)
  • 2002-2005 VW Beetle Secondary Electric Air Pump for L4 1.8L
  • 2001-2002 VW Cabrio Secondary Electric Air Pump
  • 2001 VW Eurovan Secondary Electric Air Pump for V6 2.8L (Engine ID AKX)
  • 2002-2003 VW Eurovan Secondary Electric Air Pump
  • 2000-2001 VW Golf Hatchback Secondary Electric Air Pump for L4 2.0L
  • 2002-2005 VW Golf Secondary Electric Air Pump for L4 2.0L
  • 2003-2005 VW Golf Secondary Electric Air Pump for V6 2.8L
  • 2004 VW Golf Secondary Electric Air Pump for V6 3.2L
  • 2006 VW Golf Secondary Electric Air Pump for L4 2.0L (8th Vin Digit J)
  • 2000-2005 VW Jetta Secondary Electric Air Pump for L4 2.0L
  • 2002-2005 VW Jetta Secondary Electric Air Pump for V6 2.8L (Engine ID BDF)
  • 2000 VW Passat Secondary Electric Air Pump (From VIN 250001)
  • 2001-2005 VW Passat Secondary Electric Air Pump
  • 2004-2009 VW Touareg Secondary Electric Air Pump for V8 4.2L
  • 2004-2006 VW Touareg Secondary Electric Air Pump for V6 3.2L
$126.95
Save 78%
List: $575.00 Save: $448.05
Part #: 1AEAP00004

Out of Stock

Free GROUND SHIPPING

Check Shipping Rates

We're here to help

Customer Feedback

Customer Feedback
"Thanks for the fast reliable service. Great price, and the headlights were as good as oem or better!!! Keep up the good work..."
- Dwuan M.
Read More
Free Shipping!
OR
CALL
TOLL
FREE

888-844-3393

hablamos Español:866-401-3393
SHIPS SAME DAY
For Orders Placed By 5pm Est