Replaces

2003-2013 Ford Expedition Front Auto-Locking Hub Actuator Driver or Passenger Side

Part Details

  • Location: Front
  • Location: Driver or Passenger Side

This part replaces:

  • STANDARD MOTOR PRODUCTS L30001
  • DORMAN 600-105
  • OE # 7L1Z3C247A

  • New

This auto-locking hub actuator is just what you need to get your 4WD system working again!

Specifications:

  • Fits either LH (Driver Side) or RH (Passenger Side) FRONT
  • Replaces dealer part number: 7L1Z-3C247-A, 7L1Z3C247A
  • Direct replacement
  • Built to strict quality control standards

This actuator is a makes a great replacement and has good cost savings over the dealer part!

Lifetime Warranty

This item is backed by a Limited Lifetime Warranty. In the event this item should fail due to manufacturing defects during intended use, we will exchange the part free of charge (excludes shipping charges) for the original purchaser. Please keep your invoice for proof of this warranty.

  1. Raise and Secure the Vehicle (1:08 in the video)
    • Raise the vehicle with a jack
    • Secure the vehicle on jack stands
  2. Removing the CV Axle Shaft (1:08 in the video)
    • Pry off the wheel center cap with a flat blade screwdriver
    • Remove the cap over the hub nut
    • Remove the 13mm hub nut
    • While holding the tire in place, remove the six twelve-point 12mm bolts from the CV joint
    • Remove the 30mm bolt from the strut assembly using a breaker bar or ratchet and pipe
    • Tap the nut with a hammer to loosen it, if necessary
    • Pry the lower end of the strut assembly from the lower control arm with a pry bar
    • Pull out the CV shaft
  3. Removing the Four Wheel Drive Actuator (4:03 in the video)
    • Remove the three 8mm bolts from the four wheel drive actuator
    • Pry off the actuator with a flat blade screwdriver
    • Disconnect the vacuum hoses from the actuator
  4. Installing the New Actuator (5:00 in the video)
    • Connect the vacuum hoses to the new actuator
    • Put the actuator into place
    • Start the three 8mm bolts by hand
    • Tighten the three 8mm bolts
  5. Reattaching the CV Axle (6:02 in the video)
    • Slide the CV Axle back into place
    • Reconnect the strut at the lower control arm
    • Push the bolt through where the strut connects to the lower control arm
    • Attach the nut
    • Tighten the bolt to between 95-100 foot-pounds of torque
    • Start the 12-point 12mm bolts into the CV axle by hand
    • Tighten the bolts preliminarily
    • Tighten the bolts to 25 foot-pounds in a crossing or star pattern
    • Reinstall the 13mm nut on the end of the axle
    • Reinstall the cap over the nut
    • Reinstall the center cap
    • Lower the vehicle

Tools needed for replacement:

    Pliers, Cutters & misc Wrenches

  • Slip-Joint Pliers

  • Ratchets & Related

  • 1/2 Inch Breaker Bar
  • Ratchet
  • Torque Wrench

  • Screwdrivers & Related

  • Flat Blade Screwdriver
  • Pry Bar

  • Sockets - Metric

  • 12mm Socket
  • 13mm Socket
  • 24mm Socket
  • 30mm Socket
  • 8mm Socket

  • Specialty Tools

  • A Piece of Pipe (for leverage)
  • Floor Jack
  • Hammer
  • Jack Stands

How-to Video:

(08:51 min)

Tools List:

    Pliers, Cutters & misc Wrenches

  • Slip-Joint Pliers

  • Ratchets & Related

  • 1/2 Inch Breaker Bar
  • Ratchet
  • Torque Wrench

  • Screwdrivers & Related

  • Flat Blade Screwdriver
  • Pry Bar

  • Sockets - Metric

  • 12mm Socket
  • 13mm Socket
  • 24mm Socket
  • 30mm Socket
  • 8mm Socket

  • Specialty Tools

  • A Piece of Pipe (for leverage)
  • Floor Jack
  • Hammer
  • Jack Stands



This part replaces:

  • STANDARD MOTOR PRODUCTS L30001
  • DORMAN 600-105
  • OE # 7L1Z3C247A

Vehicle Fit

  • 2003-2013 Ford Expedition Front Auto-Locking Hub Actuator Driver or Passenger Side
  • 2004 Ford F150 Heritage Truck New Body Style Front Auto-Locking Hub Actuator Driver or Passenger Side
  • 2004 Ford F150 Truck New Body Style Front Auto-Locking Hub Actuator Driver or Passenger Side
  • 2005-2013 Ford F150 Truck Front Auto-Locking Hub Actuator Driver or Passenger Side
  • 2006-2008 Lincoln Mark LT Front Auto-Locking Hub Actuator Driver or Passenger Side
  • 2003-2013 Lincoln Navigator Front Auto-Locking Hub Actuator Driver or Passenger Side
$95.45
Save 22%
List: $122.03 Save: $26.58
Part #: 1AFWA00017

- Ships Same Day for orders placed by 5 P.M. ET

Free GROUND SHIPPING

Check Shipping Rates

We're here to help

Customer Feedback

Customer Feedback
"Thanks for the fast reliable service. Great price, and the headlights were as good as oem or better!!! Keep up the good work..."
- Dwuan M.
Read More
Free Shipping!
OR
CALL
TOLL
FREE

888-844-3393

hablamos Español:866-401-3393
SHIPS SAME DAY
For Orders Placed By 5pm Est